Search Results

Diesel emissions are significant issue worldwide, and emissions requirements have become so tough that. the application of after-treatment systems is now indispensable in many countries To meet even more stringent future emissions requirements, it has become apparent that the improvement of market fuel quality is essential as well as the development in engine and exhaust after-treatment technology. Japan Clean Air Program II (JCAP II) is being conducted to assess the direction of future technologies through the evaluation of current automobile and fuel technologies and consequently to realize near zero emissions and carbon dioxide (CO2) emission reduction. In this program, effects of fuel properties on the performance of diesel engines and a vehicle equipped with two types of diesel NOx emission after-treatment devices, a Urea-SCR system and a NOx storage reduction (NSR) catalyst system, were examined.

Exhaust emissions of nitrogen oxide (NOx), total hydrocarbons (THC) and carbon mono-oxide (CO) in terms of sulfur concentration were mainly investigated according to the Japanese 10.15 mode driving schedule. Tested vehicles had direct injection engines with nitrogen oxide (NOx) selective reduction catalyst or NOx storage reduction catalyst as well as stoichiometric combustion engines with three-way catalyst. Direct continuous measurement of NOx, THC and CO was also conducted. Exhaust Emissions were measured using He injection and mass spectrometry. The air fuel ratio (AFR) and driving conditions that would promote sulfur removal were found to be important factors in reducing NOx further, for recent gasoline-fueled vehicles with emerging technologies using low sulfur fuels under 100 ppm.

Evaporative emissions of Japanese older and current vehicles (1990-1998MY) and U.S. current vehicles, which were adapted to federal regulations in 1996, were investigated using typical Japanese gasoline. Japanese older and current vehicles exhibited high levels of Running Loss (RL), Hot Soak Loss (HSL) and Diurnal Breathing Loss (DBL), and their emissions showed strong Reid vapor pressure (RVP) dependence. On the other hand, U.S. vehicles showed very weak RVP dependence, between 62kPa and 76kPa. Their emissions also showed very low levels of RL, HSL and DBL. These results suggest RVP reduction is just effective for Japanese older and current vehicles. Evaporative emissions of Japanese and U.S. vehicles were also tested according to a new Japanese test procedure and the 35 degrees centigrade RL test procedure. In the case of the RL and DBL tests, the impact of test conditions on evaporative emissions was discussed as well.