A Study of VOC Running Losses from European Canister-Equipped Vehicles 930945
Six European vehicles fitted with carbon canisters have been tested under severe conditions to establish if evaporative losses of volatile organic compounds occur under European driving conditions - so-called “running losses”. The programme entailed the development of a point source measurement technique which has a number of advantages over other methods currently in use.
Following the development and validation of the measurement technique, the six vehicles were tested at 28C over a range of driving cycles on a gasoline with a Reid vapour pressure of 90 kPa. None of the vehicles exhibited classical running losses, i.e. losses during higher-speed driving. This was due to the effectiveness of canister purging in these conditions.
However, significant volatile organic compound (VOC) losses were observed for several vehicles during idle after a period of driving had heated the fuel. Substantial car-to-car variation was observed in the losses obtained. The losses were always more severe over longer idling periods, and more severe than hot soak over comparable periods. This may have important implications for urban pollution.
Critical factors affecting running losses are fuel temperature and purging strategy. Higher fuel temperatures increase vapour generation and hence the canister charging rate. Purging rates must be sufficient to overcome the charging rate. Larger carbon canisters (LCC) were found to be more effective than small carbon canisters (SCC) in reducing running/idling losses because of the extra adsorbent capacity available. Mitigation of refuelling losses is an added benefit. Systems that combine the canister with a pressurized fuel tank, in order to limit VOC charging of the canister, were shown to run the risk of VOC losses from sources other than the canister vent.
Citation: Morgan, T., Betts, W., Hutcheson, R., McArragher, J. et al., "A Study of VOC Running Losses from European Canister-Equipped Vehicles," SAE Technical Paper 930945, 1993, https://doi.org/10.4271/930945. Download Citation
Author(s):
T. B. D. Morgan, W. E. Betts, R. C. Hutcheson, J. S. McArragher, H. P. Schmiedel, D. G. Snelgrove
Affiliated:
CONCAWE
Pages: 18
Event:
International Congress & Exposition
ISSN:
0148-7191
e-ISSN:
2688-3627
Also in:
U.S. and European Automotive Emissions Technology-SP-0957
Related Topics:
Volatile organic compounds
Fuel tanks
Pressure
SAE MOBILUS
Subscribers can view annotate, and download all of SAE's content.
Learn More »
